Articles

  1. Home
  2. Quarry Dust As Substitute Material In Concrete

Quarry Dust As Substitute Material In Concrete

Send Enquiry

Here you can submit any questions and we will get back to you as soon as possible. We will not disclose the information you submit to anyone, please rest assured.

  • EXPERIMENTAL INVESTIGATION OF PARTIAL

    EXPERIMENTAL INVESTIGATION OF PARTIAL

    2016-4-20are preferably by products. Quarry dust has been proposed as an alternative to river sand that gives additional benefit to concrete. Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand, but it causes a reduction in the

  • EXPERIMENTAL STUDY O N BACTERIAL RICE HUSK ASH

    EXPERIMENTAL STUDY O N BACTERIAL RICE HUSK ASH

    2017-4-28structure. So there is a need to use microbial material which self heals the cracks present in the concrete. In the present study, bacillus subtilis was used as a microbial material for the preparation of bacterial concrete. Control concrete was prepared for comparison with bacterial concrete. Rice husk ash RHA and Quarry dust QD are

  • International Journal of Innovative Technology and ...

    International Journal of Innovative Technology and ...

    2015-12-2in workability of concrete 2. Quarry dust has been proposed as an alternative to river sand that gives additional benefit to concrete. Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand, but it causes a reduction in the workability of concrete

  • Effect of Partial Replacement of Sand with Quarry Dust on ...

    Effect of Partial Replacement of Sand with Quarry Dust on ...

    2018-7-5with quarry dust. The experimental results suggest that the concrete mixed with quarry dust could be used in the general concrete project since there is an increase in a certain percentage replacement in the strength of the concrete. Key words Sand, Quarry Dust, Properties of Concrete

  • STUDY ON STRUCTURAL PROPERTIES OF CONCRETE BY

    STUDY ON STRUCTURAL PROPERTIES OF CONCRETE BY

    2018-8-31in fly ash and quarry dust concrete specimens while casting process. In this study the advanced method of chloride penetration method RCPT was conducted for the fly ash and quarry dust concrete. Finally this study shows the structural properties like compressive strength, split tensile strength and flexural strength of fly ash and quarry

  • Experimental Study on Partial Replacement of Fine ...

    Experimental Study on Partial Replacement of Fine ...

    2018-3-10of concrete by adding quarry dust and red soil with concrete. 5. PREVIOUS STUDY Sumit L 2015 The author says, This paper reports the experimental study which investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete quarry dust M 20, and M25.

  • An Experimental Study on Strength of Concrete with

    An Experimental Study on Strength of Concrete with

    2019-10-122.4 Quarry Dust Quarry dust is the waste product of quarrying processing.Quarry Dust confirming to Zone II with specific gravity 2.5 is taken. The testing of QD was done as per IS383-1970. Fig. 2 Quarry Dust 2.5 Mix proportion Concrete mix design in made as per IS 10262-2009 for M20 grade of Concrete with watercement ratio 0.46.

  • Strength and durability properties of concrete containing ...

    Strength and durability properties of concrete containing ...

    2008-11-9has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10 more than the conventional concrete. Keywords concrete, quarry rock dust, river sand, strength, properties ...

  • Partial Replacement of Sand with Quarry Dust in

    Partial Replacement of Sand with Quarry Dust in

    2019-10-26-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.

  • Dust Partial Replacement of Fine Aggregate by Quarry ...

    Dust Partial Replacement of Fine Aggregate by Quarry ...

    2018-6-9obtained, it is clear that quarry dust can be used as a good substitute the partial replacement of sand in the concrete. Keywords Quarry Dust, Concrete, Compressive Strength, Tensile Strength 1. Introduction Cement is a binding substance that sets and hardens and can bind other materials together.

  • Investigation of the Use of Quarry Dust as a Substitute

    Investigation of the Use of Quarry Dust as a Substitute

    2019-12-18This project report on investigation of the use of quarry dust as a substitute of river sand in concrete mixes contains figures, table of contents, nomenclature, slump test, data analysis and presentation, research methodology, the effect of shape and texture of fine aggregate, properties of concrete, concrete ratios, etc.

  • EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

    EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

    2015-4-21EXPERIMENTAL STUDY ON REPLACEMENT OF FINE AGGREGATE BY QUARRY DUST IN CONCRETE Vijay P Gowda1, Dinesh1, Kiran muchandi1, Avinash1 and Kumar S1 The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as

  • Suitability of Quarry Dust as Partial Replacement Material ...

    Suitability of Quarry Dust as Partial Replacement Material ...

    Suitability of Quarry Dust as Partial Replacement Material for Sand in Concrete S. N. Ramana, M. F. M. Zainb, H. B. Mahmuda, K. S. Tanb aDepartment of Civil ...

  • Quarry Dust Uses in a Construction Project

    Quarry Dust Uses in a Construction Project

    Quarry dust a by- product from crushing process during quarrying activities is good alternative during construction projects. ... quarry dust, quarry dust concrete, quarry dust uses. previous article. Top benefits of using paving blocks in construction. next article. Where to Buy Cost-Effective Quarry Stones ... Types of Construction Material ...

  • Quarry Dust Concrete - atelier-eemster24.nl

    Quarry Dust Concrete - atelier-eemster24.nl

    Study on Compressive Strength of Quarry Dust as Fine ... c The compressive strength results of quarry dust concrete cubes were obtained in the third series, where M20, M25, and M30 grades of concrete with 20, 25, and 30 percent replacement of quarry dust and also workability are studied by varying the water-cement ratio

  • Analysis of the Compressive Strength of Concrete with ...

    Analysis of the Compressive Strength of Concrete with ...

    age compressive strength of concrete cubes made with 100 quarry dust. There is approximately 12 increase on aver-age compressive strength of concrete made with 50 quarry dust and 50 sand as compared to that made of 100 sand controlattheendof21days. AccordingtoNeville,concreteofgradeC20at28daysmust achieve a compressive strength of 20MPa.

  • Studies on Quarry Dust as Partial Replacement of Fine ...

    Studies on Quarry Dust as Partial Replacement of Fine ...

    2017-4-30to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results of this investigation 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20 replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3.

  • MECHANICAL PROPERTIES OF M25 M30 GRADE LIGHT

    MECHANICAL PROPERTIES OF M25 M30 GRADE LIGHT

    2017-12-29Mechanical properties of M25 M30 Grade Light weight Concrete with Quarry dust as Replacement International Conference on Recent Trends in Environmental Science and Engineering RTESE17, APSCE, Bengaluru, India, 16th December, 2017, ISBN 978-93-87405-83-7

  • Effect of Quarry Dust as Partial Replacement of Sand in ...

    Effect of Quarry Dust as Partial Replacement of Sand in ...

    property of quarry dust and the suitability of those properties to enable quarry dust Celik et. al., 1996 to be used as partial replacement material for sand in concrete. The use of quarry dust in concrete is desirable because of its benefits such as useful disposal of by products, reduction of river sand consumption as well

  • application of quarry dust in concrete construction - Flat

    application of quarry dust in concrete construction - Flat

    2019-12-14Usually, Quarry Rock Dust is used in large scale in the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements. Use of Quarry rock dust as a fine aggregate in concrete draws serious attention of researchers and investigators.

  • High-strength rice husk ash concrete incorporating

    High-strength rice husk ash concrete incorporating

    2017-8-25concrete 4. Addition of RHA into concrete also causes significant High-strength rice husk ash concrete incorporating quarry dust as a partial substitute for sand T. Ngoa, P. Mendisa, H.B. MahmudC S.N. Raman a Department of Civil Environmental Engineering, The University of Melbourne, Victoria 3010, Australia

  • Behaviour of Concrete on the Use of Quarry Dust and ...

    Behaviour of Concrete on the Use of Quarry Dust and ...

    2019-10-12purpose. Quarry dust being non-biodegradable material, it takes years to decompose, therefore its use in construction industry reduces the space required for landfilling the quarry dust. The chemical composition of river sand and quarry dust are almost similar. In this we study the efficiency of using quarry dust in concrete by

  • quarry dust as substitute material in concrete -

    quarry dust as substitute material in concrete -

    quarry dust as substitute material in concrete. Chili 120-150tph Station de concassage mobile de pierre de rivire. Chili 120-150tph Station de concassage mobile de pierre de rivire. Ligne de concassage de minerai de fer du Chili. Papouasie Nouvelle Guine 250TPH Station de concassage mobile.

  • QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE

    QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE

    2016-9-9QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE AGGREGATES IN CONCRETE MIX Syed Afzal Basha . Sr. Asst Professor - Dept of Civil Engg . G Pullaiah College of Engg Technology, Kurnool . Abstract Large quantum of concrete is being used for construction industry all over the world. One of the essential ingredients of concrete is river sand in ...

  • Study of Compressive Strength of Concrete by Partially ...

    Study of Compressive Strength of Concrete by Partially ...

    2017-10-30getting quarry dust easily and it is eco Friendly also so we can use quarry dust as a substitute for fine aggregate and we can check the strength, if strength remains same we can replace quarry dust as a substitute in the construction fields. In the production of concrete

  • I am using quarry dust fine like cement as a partial ...

    I am using quarry dust fine like cement as a partial ...

    It is good to be creative and to think outside the square. However there are sometimes that things have been done a certain way for a long time for a good reason. The problem is that using what I would call crusher dust or crusher fines will ...